Adsorbent Characteristics of Malachite Green—A Short Review
Keywords:
Malachite green, Synthetic dye, Adsorption, thermodynamics, Environmental pollution, Textile industryAbstract
Dyes are widely used in textiles, paper and pulp, leather, cosmetics and food processing industries. Due to rapid development of modern textile industry a large amount of industrial effluent containing dyes have been discharged into the aquatic environment. Environmental pollution due to dye containing effluents has intensified over the years. Most of the synthetic dyes are toxic in nature, non bio-degradable and stable to light and hence cause severe physiological effect to living organism. Malachite green is a synthetic dye which is widely used in textile industry. There is different techniques viz. coagulation – flocculation, membrane filtration, oxidative method, bioaccumulation, biosorption etc. for removal of dyes from wastewater. Among the all techniques, adsorption is preferred due to its simplicity, availability of various types of adsorbents, reusability and also the cost effectiveness. This short review article mainly highlights on the recent progress of adsorption technique for removal of malachite green summarizing adsorbents characterization, as well as the isotherm, thermodynamics and kinetics of adsorptive removal
of malachite green.
References
N. Nasuha, B.H. Hameed,Adsorption of methylene blue from aqueous solution onto NaOH-modified rejected tea, Chemical Engineering Journal, 166(2) (2011) 783-786.
R. Kant, Textile dyeing industry an environmental hazard,Natural Science 04(01) (2012) 22–26.
M. A. Rauf, S.S. Ashraf, Survey of recent trends in biochemicallyassisted degradation of dyes, Chemical Engineering Journal 209 (2012) 520–530, https://doi.org/10.1016/j.cej.2012.08.015.
S. Byadgi, Decolourization of textile dye effluents, Environment, 3 (2015) SlideShare. https://www.slideshare.net/Shameem_Byadgi/decolourization-oftextile-dye-effluents.
A. Elhalil, H. Tounsadi, R. Elmoubarki, F.Z. Mahjoubi, M. Farnane, M. Sadiq, M. Abdennouri, S. Qourzal, N. Barka, Factorial experimental design for the optimization of catalytic degradation of malachite green dye in aqueous solution by Fenton process, Water Resources and Industry, 15 (2016) 41–48.
S. Srivasstava, R. Sinha, D. Roy, Toxicological effect of malachite green , Aquatic Toxicology, 66(3) (2004) 319-329.
M.Ullah, L. A. Shah, M.Sayed, M. Siddiq, N U. Amin, Micellar supported ultrafiltration of malachite green: Experimental verification of theoretical approach,ZeitschriftfürPhysikalischeChemie, (2018)DOI: 10.1515/zpch-2017-1068.
S. Hashemian,Fenton-like oxidation of malachite green solutions: Kinetic and thermodynamic study,Journal of Chemistry, 809318 (2013), https://doi.org/10.1155/2013/809318.
V. Chaturvedi, P. Verma, Biodegradation of malachite green by a novel copper tolerant Ochrobactrum pseudogrignonense strain GGUPV1 isolated from copper mine waste water. Bioresour. Bioprocess. 2, 42 (2015).https://doi.org/10.1186/ s40643-015-0070-8.
Z. Chen, H. Deng, C. Chen, Y. Yang, H. Xu,Biosorption of malachite green from aqueous solutions by Pleurotusostreatus using Taguchi method,Journal of Environmental Health Science and Engineering, 12: 63(2014) doi: 10.1186/2052-336X-12-63.
T.P. Krishna Murthy, B.S.Gowrishankar, M.N. Chandra Prabhaa, M. Kruthi, R. Hari Krishna, Studies on batch adsorptive removal of malachite green from synthetic wastewater using acid treated coffee husk:Equilibrium, kinetics and thermodynamic studies, Microchemical Journal, 146 (2019) 192–201.
W. Qu., T. Yuan, G. Yin., S. Xu, Q. Zhang, H. Su, Effect of properties of activated carbon on malachite green adsorption, Fuel, 249 (2019) 45–53.
E. B. Azimi, A. Badiei, J. B. Ghasemi, Efficient removal of malachite green from wastewater by using boron-doped mesoporous carbon nitride, Applied Surface Science, 469 (2019) 236–245.
T.K. Arumugam, P. Krishnamoorthy , N.R. Rajagopalan, S. Nanthini , D. Vasudevan,, Removal of malachite green from aqueous solutions using a modified chitosan composite, International Journal of Biological Macromolecules, 128 (2019) 655–664.
S. Hajialigol, S. Masoum, Optimization of biosorption potential of nano biomass derived from walnut shell for the removal of Malachite Green from liquids solution: Experimental design approaches, Journal of Molecular Liquids, 286 (2019) 110904.
F. Mashkoor, A.Nasar, Preparation, characterization and adsorption studies of the chemically modified Luffaaegyptica peel as a potential adsorbent for the removal of malachite green from aqueous solution, Journal of Molecular Liquids, 274 (2019) 315–327.
M. Mobarak, E. A. Mohamed, A. Q. Selim, M.F. Eissa, M. K. Seliem, Experimental results and theoretical statistical modeling of malachite green adsorption onto MCM–41 silica/rice husk composite modified by beta radiation, Journal of Molecular Liquids, 273 (2019) 68–82.
S.A. Sadat, A.Ghaedi, M. Panahimehr, M.M. Baneshi, A. Vafaei, M Ansarizadeh, Rapid roomtemperature synthesis of cadmium zeoliticimidazolate framework nanoparticles based on 1,1′-carbonyldiimidazole as ultra-highefficiency adsorbent for ultrasound-assisted removal of malachite green dye, Applied Surface Science, (2019) 1204–1212.
F. Ramezani, R. Zare-Dorabe, Simultaneous ultrasonic-assisted removal of malachite green and methylene blue from aqueous solution by Zr-SBA-15, Polyhedron, 166 (2019) 153–161.
R. Bagheri , M. Ghaedi , A. Asfaram , E. A. Dil, H. Javadian, RSM-CCD design of malachite green adsorption onto activated carbon with multimodal pore size distribution prepared from Amygdalusscoparia: Kinetic and isotherm studies, Polyhedron, 171 (2019) 464–472.
X. Pan, G. Zuo, T. Su, S. Cheng, Y. Gu, X. Qi, W. Dong, Polycarboxylic magnetic polydopamine sub-microspheres for effective adsorption of malachite green, Colloids and Surfaces A, 560 (2019) 106– 113.
M. Gao, Z. Wang, C.Yang, J. Ning, Z. Zhou, G. Li, Novel magnetic graphene oxide decorated with persimmon tannins for efficient adsorption of malachite green from aqueous solutions, Colloids and Surfaces A, 566 (2019) 48–57.
M. R. Abukhadra, M. A. Sayed, A. M. Rabie, S. A. Ahmed, Surface decoration of diatomite by Ni/NiO nanoparticles as hybrid composite of enhanced adsorption properties for malachite green dye and hexavalent chromium, Colloids and Surfaces A, 577 (2019) 583–593.
N. A. H. M. Zaidi, L. B. L. Lim, A. Usman, Enhancing adsorption of malachite green dye usingbase-modifiedArtocarpusodoratissimus leaves as adsorbents, Environmental Technology & Innovation, 13 (2019) 211–223.
A. Dehbi, Y. Dehmani. H. Omari, A. Lammini, K. Elazhari, A. Abdallaoui, Hematite iron oxide nanoparticles (α-Fe2O3): Synthesis and modelling adsorption of malachite green, Journal of Environmental Chemical Engineering, (2019) https://doi.org/10.1016/j.jece.2019.103394.
M. S. Bashanaini, M. H. Al-Douh, H. S. Al-Ameri, Removal of malachite green dye from aqueous solution by adsorption using modified and unmodified local agriculture waste, Science Journal of Analytical Chemistry, 7(2) (2019) 42-56.
N. G. Zaharaddeen, S. M. Magami, B. M. Ibrahim, equilibrium adsorption of malachite green dye onto defatted papaya seed, FUDMA Journal of Sciences, 3(2) (2019) 67-76.
B.A.P. dos Santos, A.S. Cossolin, H.C. O. dos Reis, K.C. de Castro, E.R. da Silva, G.M. Pereira, P.T.S. Junior, E.L. Dall'Oglio, L.G. deVasconcelos, E.B. de Morais, Baker’s yeast-MnO2 composites as biosorbent for Malachite green: An ecofriendly approach for dye removal from aqueous solution, Ambiente&Água - An Interdisciplinary Journal of Applied Science,(2019) ISSN 1980-993X – doi:10.4136/1980-993X.
Y, İ. Coşkun, N. Aksuner, J. Yanik, Sandpaper wastes as adsorbent for the removal of brilliant green and malachite green dye,ActaChimica Slovenica, 66 (2019)402–413.
S. D. Abkenar, M. Hassannezhad, M. Hosseini, M.R. Ganjali, Efficient removal of Malachite Green from aqueous solution by adsorption on carbon nanotubes modified with ZnFe2O4 nanoparticles, Journal of Serbian Chemical Society, 84 (7) (2019)701–712.
A. A. Fodeke, O. O. Olayera, Thermodynamics of adsorption of malachite green hydrochloride on treated and untreated corncob charcoal,Journal of Serbian Chemical Society, 84 (10) (2019) 1143–1154.
A. A. Adeyi , S. N. A. M. Jamil, L. C. Abdullah ,T. S. Y. Choong, Adsorption of Malachite Green Dye from Liquid Phase Using Hydrophilic Thiourea-Modified Poly(acrylonitrile-co-acrylic acid): Kinetic and isotherm studies, Journal of Chemistry,4321475(2019) https://doi.org/10.1155/2019/4321475.
F. Borousan, F. Yousefi, M. Ghaedi, Removal of malachite green dye using IRMOF-3−MWCNTOH− Pd-NPs as a novel adsorbent: Kinetic, isotherm and thermodynamic studies, Journal of Chemical Engineering Data , 64(11) ( 2019), 4801-4814.
A. Al-Kinani, M. Gheibi, M. Eftekhari, Graphene oxide–tannic acid nanocomposite as an efficient adsorbent for the removal of malachite green from water samples, Modeling Earth Systems and Environment, 5 (2019) 1627–1633.
B.K. A. Al–Roos, S. H. Lubbad,K. K. Abu–Saqer, Assessment of thermally treated sphagnumpeat moss sorbents for removal of phenol red, bromothymol blue and malachite green fromaqueous solution, International journal of Environmental Studies, 76( 5) (2019) 861–872.
I. Ali, C. Peng, I. Naz, D. Lin, D. P. Saroj, M. Ali, Development and application of novel biomagnetic membrane capsules for the removal of the cationic dye malachite green in wastewater treatment, RSC Advance, 9 ( 2019) 3625.
S.Huo, C. Liu, P. Zhou, J. Yu, L. Bai, Z.Han, X. Lu, Recyclable magnetic carbonaceous porous composites derived from MIL-100(Fe) for superior adsorption and removal of malachite green fromaqueous solution, RSC Advance, 9 (2019) 23711.
H.A. Chanzu, J. M. Onyari, P. M. Shiundu, Brewers’ spent grain in adsorption of aqueous Congo Red and malachite Green dyes: Batch and continuous flow systems, Journal of Hazardous Materials, 380 (2019) 120897.
M. Iqbal, D. Datta, Competitive removal of malachite green and rhodamine-B using Amberlite-XAD- 4 impregnated with Aliquat 336: experimental and modeling studies, Separation Science and Technology, (2019) DOI: 10.1080/01496395.2019.1568477.
. M. Das, C. Mishra, Jackfruit leaf as an adsorbent of malachite green: recovery and reuse of the dye, SN Applied Sciences, 1:483 (2019) https://doi.org/10.1007/s42452-019-0459-7.
F. A. Dawodu, C. U. Onuh, K. G. Akpomie, E. I. Unuabonah, Synthesis of silver nanoparticle from Vignaunguiculatastem as adsorbent for malachite green in a batch system, SN Applied Sciences, 1:346
(2019) https://doi.org/10.1007/s42452-019-0353-3
K. Boutemak, B. Cheknane, N. Taoualit, H. Ammour, Sorption of Malachite green and Rhodamine- B dyes from aqueous solution by biomass waste: Kinetics, isotherm and thermodynamic studies, Indian Journal of Chemical Technology, 26(2019) 252-257.
U. Jinendra, Jeethendr, B. M. Nagabhushana, A. V. Raghu,D. Bilehal, Facile Synthesis of CoFe2O4 nanoparticles and their application in removal of malachite green dye, Green Materials, 7(3) (2019) 137-142.
M. A. Khan, M. Otero, M. Kazi, A. A. Alqadami, S. M. Wabaidur, M.R. Siddiqui, Z. A. Alothman, S. Sumbul, Unary and binary adsorption studies of lead and malachite green onto a nanomagnetic copper ferrite/Drumstick pod biomass composite, Journal of Hazardous Materials, 365 (2018) DOI: 10.1016/j.jhazmat.2018.11.072
S.Lee, J. Park, S. Kim, S. Kang, J. Cho, J. Jeon ,Y. Lee, D. Seo, Sorption behavior of malachite green onto pristine lignin to evaluate the possibility as a dye adsorbent by lignin,AppliedBiologicalChemistry, 62:37(2019)
https://doi.org/10.1186/s13765-019-0444-2
M. Mohamad, R. Mohammad, T. S. May, L. J. Wei, Removal of malachite green by sugarcane bagassebiochar using response surface methodology, AIP Conference Proceedings 2068, 020029 (2019) https://doi.org/10.1063/1.5089328.
Z. Benmaamar,H. Boutoumi,H. Hamitouche,H. Benmaamar,A. Benmaamar,A. Benmaamar, A. Aggoun, Simulation of adsorption kinetics of malachite green onto activated carbon,PortugaliaeElectrochimicaActa, 37(2) (2019) 93-104.
X. Xing, X. Zhang, K. Zhang, L.Jin , Q. Cao, Preparation of large-sized graphene from needlecoke and the adsorption for malachite green with its graphene oxide, Fullerenes, Nanotubes and Carbon Nanostructures, 27(2) (2018) 97-105, DOI:10.1080/1536383X.2018.1512099.
J. Rai, D. Kumar, J.P. Gaur, Sorption of malachite green (a cationic dye) and heavy metals by dead biomass of Phormidesmismolle(cyanobacteria)-dominated mat, Water and Environment Journal,33 (2019) 51–60.
M. Rajabi, K. Mahanpoor, O. Moradi, Preparation of PMMA/GO and PMMA/GO-Fe3O4 nanocomposites for malachite green dye adsorption: Kinetic and thermodynamic studies, Composites Part B: Engineering, 167(2019) 544-555.
C. De Marco, R. S. Mauler, T. S. Daitx, I. Krindges, A. Cemin, L. R. Bonetto, J. S.Crespo, R. Guégan, L. N. Carli , M. Giovanela, Removal of malachite green dye from aqueous solutions by a magnetic adsorbent, Separation Science and Technology,(2019) DOI:10.1080/01496395.2019.1585455
E. Sharifpour, E. A. Dil, A. Asfaram,M. Ghaedi, A. Goudarzi, Optimizing adsorptive removal of malachite green and methyl orange dyes from simulated wastewater by Mn‐doped CuO‐Nanoparticles loaded on activated carbon using CCD‐RSM: Mechanism, regeneration, isotherm, kinetic, and thermodynamic studies, Applied Organometallic Chemistry, e4768( 2019) https://doi.org/10.1002/aoc.476.
X. H. Song, K. L. Goh , K. Wang, The equilibrium and fixed-bed study of malachite green adsorption on chitosan hydrogels, Water Science andTechnology, 79 (8) (2019) 1571–1579.
G. Sriram, U.T. Uthappa, M. Kigga,H. Jung, T. Altalhi, V. Brahmkhatri, M.D. Kurkuri, Xerogel activated diatom as an effective hybrid adsorbent for the efficient removal of malachite green, New Journal of Chemistry, 43 (2019) 3810-3820.
S.M. Yusoff, W. S. W. Ngah, F. S. Mehamod, F. B. M. Suah , Adsorption of malachite green onto modified chitosan–sulfuric acid beads: a preliminary study, Malaysian Journal of Analytical Sciences, 23 (4 ) (2019) 625 - 636
P. Wadhera ,R. Jindal, R. Dogra, Synthesis of Semi Interpenetrating Network Hydrogel [(GrA-Psy)- cl-Poly (AA)] and its Application for Efficient Removal of Malachite Green from Aqueous Solution, Polymer Engineering and Science,59(7) (2019) 1416-1427.
X. Tang, F. Zhang, Y. Huang, A. A. Keller, J. Lan, Competitive removal of Pb2+ and malachite green from water by magnetic phosphate nanocomposites, Water Research, 150 (2019) 442-451.
N. Ayawei, S. S. Angaye, D. Wankasi, and E. D. Dikio, Synthesis, characterization and application of Mg/Al layered double hydroxide for the degradation of congo red in aqueous solution,Open Journal of Physical Chemistry, 5(03)(2015) 56–70.
N. Ayawei, A. T. Ekubo, D. Wankasi, and E. D. Dikio, Adsorption of congo red by Ni/Al-CO3: equilibrium, thermodynamic and kinetic studies,Oriental Journal of Chemistry, 31(30) (2015) 1307–1318.
I. Langmuir,The constitution and fundamental properties of solids and liquids. Journal of American Chemical Society, 38(1916) 2221–2295.
H.M.F.Freundlich,Over the adsorption in solution,Journal of PhysicalChemistry, 57(1906) 385–471.
R. Sips,Combined form of Langmuir and Freundlich equations, The Journal of ChemicalPhysics, 16 (1948) 490–495.
O. Redlich,D.L.Peterson,A useful adsorption isotherm,The Journal of Chemical Physics, 63(1959) 1024–1026.
M. M. Dubinin, The potential theory of adsorption of gasses and vapours for adsorbents with energetically non-uniform surface, ChemicalReviews, 60 (1960) 235-266.
M.I.Temkin, V. Pyzhev, Kinetics of ammonia synthesis on promoted iron catalysts. ActaPhysiochimica URSS12(1940) 217-222.
M.S. Mansour, M.E. Ossman, H.A. Farag, Removal of Cd(II) ion from waste water 571 by adsorption onto polyaniline coated on sawdust, Desalination, 272 (1–3) 572 (2011) 301–305, doi:http://dx.doi.org/10.1016/j.desal.2011.01.037.
A.K. Singh, D.P. Singh, K.K. Pandey, V.N. Singh, Wollastonite as sorbent for 573 removalFe(II) from water, Journal of Chemical Technology, 42 (1988) 39–47.
G. Blanchard, M. Maunaye, G. Martin, Removal of heavy metals from waters by 574 means of natural zeolites, Water Resources, 18 (12) (1984) 1501–1507, doi:http://dx. 575 doi.org/1 0.1016/0043- 1354(84)90124-6.
Y.S. Ho, G. Mckay, Kinetic models for the sorption of dye from aqueous solution 576 by wood, Process Safety and Environmental Protection, 76 (2) (1998) 183–191, doi:http://dx.doi.577 org/10.1205/095758298529326.
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2023 Teachers' Journal
This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.
